Zvezda module on ISS is leaking once again
According to a report today at Ars Technica, the Zvezda module on ISS is once again leaking station air, despite recent repairs to the stress fractures in its hull that had appeared in recent months to halt the air loss.
After a couple of sources reported this to Ars, NASA confirmed the issue on Thursday. On May 1, after Russian cosmonauts unloaded cargo from the Progress 95 cargo spacecraft, Roscosmos noted a “slow pressure drop” in the PrK module.
“Teams performed data analysis, which indicated a loss of about one pound per day,” NASA spokesperson Josh Finch told Ars. “Roscosmos allowed the pressure in the transfer tunnel to gradually decrease while monitoring the rate. The area now is being maintained at a lower pressure, with small repressurizations as needed. There are no impacts to station operations, and NASA and Roscosmos are coordinating on next steps.”
A loss of one pound of air per day is comparable to the leak rate back in 2019, as shown in the lower right corner of the graphic below. It is also one third the loss rate seen for much of the following five years, which is I suppose good news.
Figure 3 from September 2024 Inspector General report, showing Zvezda’s location on ISS, as well as the station’s leak rate at that time.
At the same time, it suggests once again that every docking to Zvezda puts stress on its hull, and apparently causes either new cracks or the reopening of old ones. In such a situation, a catastrophic failure of the module remains a possibility that cannot be dismissed. NASA closes the hatch between the Russian and American halves of the station whenever there is a docking, but that is only band-aid covering a much more serious problem.
Without question ISS’s life span is impacted by this issue. The sooner the U.S. can replace it with at least one or two of the private commercial stations under development, the better.
On Christmas Eve 1968 three Americans became the first humans to visit another world. What they did to celebrate was unexpected and profound, and will be remembered throughout all human history. Genesis: the Story of Apollo 8, Robert Zimmerman's classic history of humanity's first journey to another world, tells that story, and it is now available as both an ebook and an audiobook, both with a foreword by Valerie Anders and a new introduction by Robert Zimmerman.
The print edition can be purchased at Amazon or from any other book seller. If you want an autographed copy the price is $60 for the hardback and $45 for the paperback, plus $8 shipping for each. Go here for purchasing details. The ebook is available everywhere for $5.99 (before discount) at amazon, or direct from my ebook publisher, ebookit. If you buy it from ebookit you don't support the big tech companies and the author gets a bigger cut much sooner.
The audiobook is also available at all these vendors, and is also free with a 30-day trial membership to Audible.
"Not simply about one mission, [Genesis] is also the history of America's quest for the moon... Zimmerman has done a masterful job of tying disparate events together into a solid account of one of America's greatest human triumphs."--San Antonio Express-News
According to a report today at Ars Technica, the Zvezda module on ISS is once again leaking station air, despite recent repairs to the stress fractures in its hull that had appeared in recent months to halt the air loss.
After a couple of sources reported this to Ars, NASA confirmed the issue on Thursday. On May 1, after Russian cosmonauts unloaded cargo from the Progress 95 cargo spacecraft, Roscosmos noted a “slow pressure drop” in the PrK module.
“Teams performed data analysis, which indicated a loss of about one pound per day,” NASA spokesperson Josh Finch told Ars. “Roscosmos allowed the pressure in the transfer tunnel to gradually decrease while monitoring the rate. The area now is being maintained at a lower pressure, with small repressurizations as needed. There are no impacts to station operations, and NASA and Roscosmos are coordinating on next steps.”
A loss of one pound of air per day is comparable to the leak rate back in 2019, as shown in the lower right corner of the graphic below. It is also one third the loss rate seen for much of the following five years, which is I suppose good news.
Figure 3 from September 2024 Inspector General report, showing Zvezda’s location on ISS, as well as the station’s leak rate at that time.
At the same time, it suggests once again that every docking to Zvezda puts stress on its hull, and apparently causes either new cracks or the reopening of old ones. In such a situation, a catastrophic failure of the module remains a possibility that cannot be dismissed. NASA closes the hatch between the Russian and American halves of the station whenever there is a docking, but that is only band-aid covering a much more serious problem.
Without question ISS’s life span is impacted by this issue. The sooner the U.S. can replace it with at least one or two of the private commercial stations under development, the better.
On Christmas Eve 1968 three Americans became the first humans to visit another world. What they did to celebrate was unexpected and profound, and will be remembered throughout all human history. Genesis: the Story of Apollo 8, Robert Zimmerman's classic history of humanity's first journey to another world, tells that story, and it is now available as both an ebook and an audiobook, both with a foreword by Valerie Anders and a new introduction by Robert Zimmerman.
The print edition can be purchased at Amazon or from any other book seller. If you want an autographed copy the price is $60 for the hardback and $45 for the paperback, plus $8 shipping for each. Go here for purchasing details. The ebook is available everywhere for $5.99 (before discount) at amazon, or direct from my ebook publisher, ebookit. If you buy it from ebookit you don't support the big tech companies and the author gets a bigger cut much sooner.
The audiobook is also available at all these vendors, and is also free with a 30-day trial membership to Audible.
"Not simply about one mission, [Genesis] is also the history of America's quest for the moon... Zimmerman has done a masterful job of tying disparate events together into a solid account of one of America's greatest human triumphs."--San Antonio Express-News
I know there is no way Russia could build any sort of replacement module. Why not give the plans and some money to a US manufacturer and build a copy of the module and launch it.
The reality is if we are to become space faring as a species, we need to learn to do this sort of thing.
As Kirk once said, “risk is our business”.
Joe asked “Why not give the plans and some money to a US manufacturer and build a copy of the module and launch it?”
We are already doing this, with five commercial stations being built by five different companies or consortiums. Each however will be new and privately owned. No reason to help the Russians prop up an old station with limited value that is owned and controlled poorly by governments.
When did they “fix” this? It wasn’t that long ago, I remember. Have there been any other docking/undockings on that port since the “fix” other than the one this week that evidently restarted the leak?