ABL completes investigation into launchpad fire in July
The rocket startup ABL yesterday released the results of its investigation into launchpad fire in July that destroyed its RS1 rocket during a static fire test prior to an orbital test launch.
In a statement, ABL Space Systems said it ignited the E2 engines in the first stage of the RS1 rocket in the test, but aborted the test after just half a second because of a low pressure reading in one engine that the company said was caused by a faulty pressure sensor. The engines shut down, but a fire then broke out under the base of the vehicle, fed by fuel leaks from two engines. That fire was contained but could not be extinguished by either water or inert gas systems, and the company started offloading kerosene and liquid oxygen propellants from the vehicle.
The launch pad the company uses at Kodiak does not have its own water supply, with the company instead using mobile tanks that ran out of water 11 and a half minutes after ignition. That caused the fire to spread “and a progressive loss of pad systems,” the company stated, including the inability to continue detanking the rocket and eventually telemetry from the rocket.
ABL’s first launch attempt of this rocket in January 2023 failed when the first stages shut down immediately after lift-off and the rocket crashed on the launchpad. It completed its investigation of that failure in October 2023 and was ready for its second launch attempt this summer when the fire described above occurred.
The company has raised several hundred million dollars, with its chief investor being Lockheed Martin, which has also signed a contract for as many as 58 RS1 launches. It increasingly appears those launches might very well go to other providers.
Readers!
Please consider supporting my work here at Behind the Black. Your support allows me the freedom and ability to analyze objectively the ongoing renaissance in space, as well as the cultural changes -- for good or ill -- that are happening across America. Fourteen years ago I wrote that SLS and Orion were a bad ideas, a waste of money, would be years behind schedule, and better replaced by commercial private enterprise. Only now does it appear that Washington might finally recognize this reality.
In 2020 when the world panicked over COVID I wrote that the panic was unnecessary, that the virus was apparently simply a variation of the flu, that masks were not simply pointless but if worn incorrectly were a health threat, that the lockdowns were a disaster and did nothing to stop the spread of COVID. Only in the past year have some of our so-called experts in the health field have begun to recognize these facts.
Your help allows me to do this kind of intelligent analysis. I take no advertising or sponsors, so my reporting isn't influenced by donations by established space or drug companies. Instead, I rely entirely on donations and subscriptions from my readers, which gives me the freedom to write what I think, unencumbered by outside influences.
You can support me either by giving a one-time contribution or a regular subscription. There are four ways of doing so:
1. Zelle: This is the only internet method that charges no fees. All you have to do is use the Zelle link at your internet bank and give my name and email address (zimmerman at nasw dot org). What you donate is what I get.
2. Patreon: Go to my website there and pick one of five monthly subscription amounts, or by making a one-time donation.
3. A Paypal Donation or subscription:
4. Donate by check, payable to Robert Zimmerman and mailed to
Behind The Black
c/o Robert Zimmerman
P.O.Box 1262
Cortaro, AZ 85652
You can also support me by buying one of my books, as noted in the boxes interspersed throughout the webpage or shown in the menu above.
The rocket startup ABL yesterday released the results of its investigation into launchpad fire in July that destroyed its RS1 rocket during a static fire test prior to an orbital test launch.
In a statement, ABL Space Systems said it ignited the E2 engines in the first stage of the RS1 rocket in the test, but aborted the test after just half a second because of a low pressure reading in one engine that the company said was caused by a faulty pressure sensor. The engines shut down, but a fire then broke out under the base of the vehicle, fed by fuel leaks from two engines. That fire was contained but could not be extinguished by either water or inert gas systems, and the company started offloading kerosene and liquid oxygen propellants from the vehicle.
The launch pad the company uses at Kodiak does not have its own water supply, with the company instead using mobile tanks that ran out of water 11 and a half minutes after ignition. That caused the fire to spread “and a progressive loss of pad systems,” the company stated, including the inability to continue detanking the rocket and eventually telemetry from the rocket.
ABL’s first launch attempt of this rocket in January 2023 failed when the first stages shut down immediately after lift-off and the rocket crashed on the launchpad. It completed its investigation of that failure in October 2023 and was ready for its second launch attempt this summer when the fire described above occurred.
The company has raised several hundred million dollars, with its chief investor being Lockheed Martin, which has also signed a contract for as many as 58 RS1 launches. It increasingly appears those launches might very well go to other providers.
Readers!
Please consider supporting my work here at Behind the Black. Your support allows me the freedom and ability to analyze objectively the ongoing renaissance in space, as well as the cultural changes -- for good or ill -- that are happening across America. Fourteen years ago I wrote that SLS and Orion were a bad ideas, a waste of money, would be years behind schedule, and better replaced by commercial private enterprise. Only now does it appear that Washington might finally recognize this reality.
In 2020 when the world panicked over COVID I wrote that the panic was unnecessary, that the virus was apparently simply a variation of the flu, that masks were not simply pointless but if worn incorrectly were a health threat, that the lockdowns were a disaster and did nothing to stop the spread of COVID. Only in the past year have some of our so-called experts in the health field have begun to recognize these facts.
Your help allows me to do this kind of intelligent analysis. I take no advertising or sponsors, so my reporting isn't influenced by donations by established space or drug companies. Instead, I rely entirely on donations and subscriptions from my readers, which gives me the freedom to write what I think, unencumbered by outside influences.
You can support me either by giving a one-time contribution or a regular subscription. There are four ways of doing so:
1. Zelle: This is the only internet method that charges no fees. All you have to do is use the Zelle link at your internet bank and give my name and email address (zimmerman at nasw dot org). What you donate is what I get.
2. Patreon: Go to my website there and pick one of five monthly subscription amounts, or by making a one-time donation.
3. A Paypal Donation or subscription:
4. Donate by check, payable to Robert Zimmerman and mailed to
Behind The Black
c/o Robert Zimmerman
P.O.Box 1262
Cortaro, AZ 85652
You can also support me by buying one of my books, as noted in the boxes interspersed throughout the webpage or shown in the menu above.
Readers: the rules for commenting!
No registration is required. I welcome all opinions, even those that strongly criticize my commentary.
However, name-calling and obscenities will not be tolerated. First time offenders who are new to the site will be warned. Second time offenders or first time offenders who have been here awhile will be suspended for a week. After that, I will ban you. Period.
Note also that first time commenters as well as any comment with more than one link will be placed in moderation for my approval. Be patient, I will get to it.